How Many Turns On Awning Spring

Prov23 4 do not wear yourself out to get rich.

How many turns on awning spring.

Jim and jennie cats bittles and potter 2000 dynasty 350 isc. If you over tighten the spring it will break. How tight can i safely read more. The unwinding can also be done while standing on the ground and the awning fully extended and the opposite side rafter locked in place.

See our channel page for link the home on the road series consists of three 2 dvd set. Travel position 9 turns. Most awnings have a spring on both ends of the tube. Severe injuries can result from the rapid spin off of the top casting.

The torsion spring will be wound with 8 eight more turns in this position and is extremely dangerous. You could consider the circumference of the tube and the length of awning fabric then add a couple more turns. Reinsert the end cap into the awning arm and install the bolt. If the springs are older and wound too tight they can break.

On the front spring counter clockwise 8 turns. Have the wisdom to show restraint. You do not need to put the screws back in. The trick is to get the awning to roll up fully and completely without slamming back against the coach.

2003 15 foot a e dometic 8500. Generally it will take six turns for awning lengths of 8 to 12 feet seven turns for 13 to 14 feet eight turns for 15 to 16 feet 10 turns for 17 to 18 feet 11 turns for 19 to 21 feet and 12 turns for 22 to 25 feet. Then the chart indicates 10 turns. This will depend on the spring and tube length.

Here s the recommended number of turns but keep in mind the older the assembly the more likely you ll have to add one or two more. Roll the awning back up to observe how tight it is. I just replaced a spring on mine and the factory rep said 7 turns for an 18 awning. If you are satisfied move on.

Remember you are adding the initial turns to the turns that the awning gets as it unrolls. Attach the vice grips to the new ratchet assembly and rotate as many turns as noted in step 6. It s best to check your rv awning manual to determine the number of turns you ll need winding up your spring. On the left spring rear turn clockwise about 8 turns.

New dometic heavy duty springs installed on a 19 8500 awning set at 8 turns do not retract the awning without me pushing it up. Extended 17 turns. Turn the spring top away from the coach.